Installing HTC Evo 4G Front Panel

Front panel replacement.

  • Add Note x
  • x 55

Remove the glass front panel to access your Evo's internals.

Sections
Tools
Tools (continued)
Relevant Parts
Image #1

Add Note Edit Step 1 — Rear Panel  ¶ 

  • Gently insert an iPod opening tool between the rear panel and the inner rear frame near the headphone jack.

  • Use your iPod opening tool to pry up the rear case around the perimeter of the Evo.

Image #1

Add Note Edit Step 2  ¶ 

  • Lift the rear panel off of the inner rear frame.

Image #1 Image #2

Add Note Edit Step 3 — Battery  ¶ 

  • Using the tip of your finger, lift the battery from the end closest to the camera.

  • Remove the battery from the rear inner frame.

Image #1

Add Note Edit Step 4 — MicroSD card  ¶ 

  • Use the flat end of a spudger to pry up the red MicroSD retainer attached to the inner frame.

  • The retainer will move about 1 mm and stop. Do not attempt to completely remove the MicroSD card retainer.

Image #1

Add Note Edit Step 5  ¶ 

  • Use a pair of tweezers to carefully pull the MicroSD card out of its slot in the inner rear frame.

Image #1

Add Note Edit Step 6 — Rear Inner Frame  ¶ 

  • Remove six T5 Torx screws securing the rear inner frame to the inner case.

Image #1

Add Note Edit Step 7  ¶ 

  • Gently insert an iPod opening tool between the rear inner frame and its plastic surround near the Micro HDMI port.

  • Carefully pry the top edge of the rear inner frame away from the front surround of the Evo.

Image #1 Image #2

Add Note Edit Step 8  ¶ 

  • Insert the iPod opening tool between the rear inner frame and its plastic surround and pry up at several points along the left edge of the Evo.

Next » « Previous

Required Tools

Spudger

$2.95 · 50+ In stock

Phillips #00 Screwdriver

$4.95 · 50+ In stock

Heat Gun

$24.95 · 25 In stock

T5 Torx Screwdriver

$6.95 · 50+ In stock

Plastic Opening Tools

$2.95 · 50+ In stock

Recommended Tools

Universal Drive Adaptor

$29.95 · 50+ In stock

iFixit Lock Pick Set

$29.95 · 30 In stock

Inspection Scope

$39.95 · 40 In stock

Frictionless Ratchet

$24.95 · 49 In stock

Portable Anti-Static Mat

$24.95 · 19 In stock

Popular Products

500 GB 7200 RPM SATA Hard Drive (New)

$109.95 · 7 In stock

Universal Drive Adaptor

$29.95 · 50+ In stock

iPhone 4S Power and Sensor Cable

$34.95 · 16 In stock

iPad 4th Gen Front Panel Assembly

$134.95 · 33 In stock

1.5" Thin Putty Knife

$6.95 · 13 In stock

Comments Add Note Comments are offturn on